1887

Abstract

Summary

This experimental study evaluates the capability of dilute nonionic surfactants for wettability alteration and enhanced oil recovery applications in carbonates.Firstly the compatibility of surfactant was determined by performing aqueous stability tests in both low salinity and high salinity brines followed by surface tension measurements to determine critical micelle concentrations (CMC). Phase behavior, and interfacialtension measurements were conducted using 0.1 wt% surfactant and crude oil at reservoir temperature. The contact angle measurements were performed using carbonate surfaces and the nonionic surfactant at dilute concentrations to evaluate wettability alterationin carbonates at reservoir conditions. Zeta potential measurements were also carried out across calcite-brine/surfactant, and crude oil-brine/surfactant interfaces to confirm the wettability alterations induced by the surfactant. Lastly microscopic dynamicliberation experiments were conducted using dilute concentrations of surfactant and polymer chemicals in both high salinity and low salinity brines to quantify the effects of wettability alteration on oil liberation efficiency in carbonates.

The compatibility of nonionic surfactant was demonstrated in high salinity brine at reservoir temperature. The critical micelle concentrations were found to bevery low in the range of 0.0020 to 0.0025 wt% in both low salinity and high salinity brines. The phase behavior results showed the formation of middle phase microemulsion and correspondingly low interfacial tensions in the range of about 0.05 mN/m with 0.1wt% surfactant in high salinity brine. The contact angle data indicated the ability of nonionic surfactant to significantly alter the wettability of carbonate from oil-wet to either intermediate wet or less oil-wet in high salinity brine whereas only marginalwettability alterations from oil-wet to less oil-wet were obtained in low salinity brine. The increasing negative zeta potentials and the alteration of charge polarity from positive to negative were observed at crude oil-brine and calcite/brine interfaces,respectively, by using 0.1 wt% surfactant in the high salinity water. Such results confirm the effectiveness of nonionic surfactant in high salinity water to alter the wettability of carbonates at dilute concentrations. The microscopic equilibrium degree ofcrude oil liberation from carbonate surface was found to be about 20% higher with high salinity surfactant-polymer solution when compared to the low salinity surfactant-polymer solution. These consistent findings obtained from different experimental techniquesclearly point out that dilute nonionic surfactant combined with dilute polymer in conventional high salinity injection water can become one potential cost-effective chemical EOR solution for oil recovery in carbonate reservoirs.

Loading

Article metrics loading...

/content/papers/10.3997/2214-4609.201900094
2019-04-08
2024-03-28
Loading full text...

Full text loading...

References

  1. Akbar, M., Vissapragada, B., Alghamdi, A.H. et al.
    2000. A Snapshot of Carbonate Reservoir Evaluation. Oil Field Review12 (4), 20–41.
    [Google Scholar]
  2. AlOtaibi, M.B. and Yousef, A.A.
    2017. The Role of Individual and Combined Ions in Waterflooding Carbonate Reservoirs: Electrokinetic Study. SPE Reservoir Evaluation & Engineering20 (1), 77–86.
    [Google Scholar]
  3. Anderson, W.G.
    1986. Wettability Literature Survey—Part 2: Wettability Measurement. Journal of Petroleum Technology38 (11), 1246–1262.
    [Google Scholar]
  4. AlSofi, A.M., Wang, J., AlBoqmi, A.M., AlOtaibi, M.B., Ayirala, S.C. and Yousef, A.A.
    2018. Smartwater Synergy with Chemical Enhanced Oil Recovery: Polymer Effects on Smartwater. SPE Reservoir Evaluation & Engineering, Preprint.
    [Google Scholar]
  5. AlSofi, A.M., Liu, J.S., and Han, M.
    2013. Numerical Simulation of Surfactant–Polymer Coreflooding Experiments for Carbonates. Journal of Petroleum Science and Engineering111, 184–196.
    [Google Scholar]
  6. Ayirala, S.C., Vijapurapu, C.S. and Rao, D.N.
    2006. Beneficial Effects of Wettability Altering Surfactants in Oil-Wet Fractured Reservoirs. Journal of Petroleum Science and Engineering52 (1–4), 261–274.
    [Google Scholar]
  7. Ayirala, S.C., Uehara-Nagamine, E., Matzakos, A.N., Chin, R.W., Doe, P.H. and van den Hoek, P.J.
    2010. A Designer Water Process for Offshore Low Salinity and Polymer Flooding Applications. Paper SPE 129926 Presented at the SPE Improved Oil Recovery Symposium, Tulsa, Oklahoma, USA, 24–28 April.
    [Google Scholar]
  8. Babadagli, T.
    2005. Analysis of Oil Recovery by Spontaneous Imbibition of Surfactant Solution. Oil & Gas Science and Technology–Rev. IFP60 (4), 697–710.
    [Google Scholar]
  9. Bagrezaie, M.A. and Pourafshary, P.
    2016. Screening and Optimisation of Water/Foam/Gas Injection EOR Scenarios in a Fractured Reservoir. International Journal of Petroleum Engineering2 (1), 1–19.
    [Google Scholar]
  10. Barnes, J.R., Smit, J., Smit, J., Shpakoff, G., Raney, K.H. and Puerto, M.
    2008. Phase Behaviour Methods for the Evaluation of Surfactants for Chemical Flooding at Higher Temperature Reservoir Conditions. Paper SPE 113314 Presented at SPE Symposium on Improved Oil Recovery, Tulsa, Oklahoma, USA, 20–23 April.
    [Google Scholar]
  11. Bu, X., Han, M. and AlSofi, A.M.
    , 2017. Core-Scale Modeling of Surfactant-Induced Spontaneous Imbibition in Carbonates. Paper SPE 186066 Presented at SPE Reservoir Characterisation and Simulation Conference and Exhibition, Abu Dhabi, UAE, 8–10 May.
    [Google Scholar]
  12. Bergh, M.
    1999. Surfactants, Their Chemistry and Properties. Acta Derm Venereol79, 5–24.
    [Google Scholar]
  13. Chen, H.L., Lucas, L.R., Nogaret, L.A.D., Yang, H.D. and Kenyon, D.E.
    2001. Laboratory Monitoring of Surfactant Imbibition with Computerized Tomography. SPE Reservoir Evaluation & Engineering4 (1), 16–25.
    [Google Scholar]
  14. Fuseni, A.B., Al-Zahrani, B.H. and AlSofi, A.M.
    2017. Critical Micelle Concentration of Different Classes of EOR Surfactants under Representative Field Conditions. Paper SPE 188011 Presented at the SPE Kingdom of Saudi Arabia Annual Technical Symposium and Exhibition, Dammam, Saudi Arabia, 24–27 April.
    [Google Scholar]
  15. Fuseni, A.B., Al-Zahrani, B.H., Al-Shehri, A.J. and AlSofi, A.M.
    , 2018. Evaluation of Surfactants Wettability Alteration Using the Washburn Contact Angle Method. Paper SPE 193751 Presented at SPE International Heavy Oil Conference and Exhibition. Kuwait City, Kuwait, 10–12 December.
    [Google Scholar]
  16. Hirasaki, G. and Zhang, D.L.
    2004. Surface Chemistry of Oil Recovery From Fractured, Oil-Wet, Carbonate Formations. SPE Journal9 (2), 151–162.
    [Google Scholar]
  17. Huang, S, and Benedetto, H.D.
    2015. Advances in Asphalt Materials. In Chapter 13: Paving with Asphaltene Emulsions, Woodhead Publishing, 393–426.
    [Google Scholar]
  18. Huh, C.
    1979. Interfacial Tensions and Solubilizing Ability of a Microemulsion Phase that Coexists with Oil and Brine. Journal of Colloid and Interface Science71, 408–426.
    [Google Scholar]
  19. Jackson, M. D., Al-Mahrouqi, D., and Vinogradov, J.
    2016. Zeta Potential in Oil-Water-Carbonate Systems and its Impact on Oil Recovery During Con-trolled Salinity Water-Flooding. Sci. Rep.6, 37363.
    [Google Scholar]
  20. Jarrahian, K., Seiedi, O., Sheykhan, M., Sefti, M.V. and Ayatollahi, S.
    2012. Wettability Alteration of Carbonate Rocks by Surfactants: A Mechanistic Study. Colloids and Surfaces A: Physicochemical and Engineering Aspects40, 1–10.
    [Google Scholar]
  21. Klins, M.A.
    1984. Carbon Dioxide Flooding–Basic Mechanisms and Project Design. International Human Resources Development Corporation, Boston.
    [Google Scholar]
  22. Masalmeh, S.K., Wei, L., Blom, C., and Jing, X.
    2014. EOR Options for Heterogeneous Carbonate Reservoirs Currently Under Waterflooding. Paper SPE 171900 presented at Abu Dhabi International Petroleum Exhibition and Conference, Abu Dhabi, UAE, 10–13 November.
    [Google Scholar]
  23. Mohammadi, M.S., Moghadasi, J. and Kordestany, A.
    2014. A Laboratory Investigation into Wettability Alteration of Carbonate Rock by Surfactants: The Effect of Salinity, pH, and Surfactant Concentration. Iranian Journal of Oil & Gas Science and Technology3 (3), 1–10.
    [Google Scholar]
  24. Qi, Z., Han, M., Fuseni, A., AlSofi, A., Zhang, F., Peng, Y. and Cai, H.
    2016. Laboratory Study on Surfactant Induced Spontaneous Imbibition for Carbonate Reservoir. Paper SPE 182322 Presented at SPE Asia Pacific Oil & Gas Conference and Exhibition. Perth, Australia, 25–27 October.
    [Google Scholar]
  25. Sandersen, S.B.
    2012. Enhanced Oil Recovery with Surfactant Flooding. PhD Thesis, Technical University of Denmark.
    [Google Scholar]
  26. Seethepalli, A., Adibhatla, B. and Mohanty, K.K.
    2004. Physicochemical Interactions during Surfactant Flooding of Fractured Carbonate Reservoirs. SPE Journal9 (4), 411–418.
    [Google Scholar]
  27. Shinoda, K.
    1978. Principles of Solution and Solubility. Marcel Dekker, New York, 157–179.
    [Google Scholar]
  28. Spildo, K., Sun, L., Djurhuus, K., and Skauge, A.
    2014. A Strategy for Low Cost, Effective Surfactant Injection. Journal of Petroleum Science and Engineering117, 8–14.
    [Google Scholar]
  29. Spinler, E. A., Zornes, D.R., Tobola, D. P. and Moradi-Araghi, A.
    2000. Enhancement of Oil Recovery Using a Low Concentration of Surfactant to Improve Spontaneous and Forced Imbibition in Chalk. Paper SPE 59290 presented at the SPE/DOE Symposium on Improved Oil Recovery, Tulsa, OK, 3–5 April.
    [Google Scholar]
  30. Standnes, D.C. and AustadT.
    2000. Wettability Alteration in Chalk: 2. Mechanism for Wettability Alteration from Oil-Wet to Water-Wet Using Surfactants. Journal of Petroleum Science and Engineering28 (3): 123–143.
    [Google Scholar]
  31. Sun, H.
    2016. Data Analysis of Surfactant-Induced Wettability Alteration in Carbonate Reservoirs. Masters Thesis. Missouri University of Science and Technology.
    [Google Scholar]
  32. Xu, W., Ayirala, S.C., and Rao, D.N.
    2008. Measurement of Surfactant-Induced Interfacial Interactions at Reservoir Conditions. SPE Reservoir Evaluation & Engineering11 (1), 83–94.
    [Google Scholar]
http://instance.metastore.ingenta.com/content/papers/10.3997/2214-4609.201900094
Loading
/content/papers/10.3997/2214-4609.201900094
Loading

Data & Media loading...

This is a required field
Please enter a valid email address
Approval was a Success
Invalid data
An Error Occurred
Approval was partially successful, following selected items could not be processed due to error